Author Topic: cleaning extractors  (Read 5844 times)

0 Members and 1 Guest are viewing this topic.

Offline ablanton

  • Regular Member
  • **
  • Posts: 95
  • Gender: Male
    • Blanton Apiaries
  • Location: Asheboro, NC
cleaning extractors
« on: June 26, 2014, 10:24:42 pm »
So, how do all of you wash your extractors?  It's a real pain in the rear.  Maybe I can learn a smarter way from somebody . . .
Andy

Offline Slowmodem

  • Gold Member
  • ****
  • Posts: 1551
  • Thanked: 37 times
  • Gender: Male
    • http://gregsbees.blogspot.com/
  • Location: Ten Mile, TN
Re: cleaning extractors
« Reply #1 on: June 26, 2014, 11:55:50 pm »
I take it to the car wash and wrap the motor in a gargage bag.  (I'd recommend avoiding the wax!  ;D )

Greg Whitehead
Ten Mile, TN
Beekeeping at 26.4 kbs

Offline pistolpete

  • Senior Member
  • ***
  • Posts: 786
  • Thanked: 20 times
  • Gender: Male
  • Location: Chilliwack, British Columbia
Re: cleaning extractors
« Reply #2 on: June 27, 2014, 12:21:29 am »
Hot water and dump the water outside.  I tried letting the bees clean is once, but when they were done with the extractor, they started on the nearest hive.
My advice: worth price charged :)

Offline apisbees

  • Global Moderator
  • Gold Member
  • *******
  • Posts: 3723
  • Thanked: 331 times
  • Gender: Male
  • Location: Vernon B.C.
Re: cleaning extractors
« Reply #3 on: June 27, 2014, 01:38:26 am »
First do not use very hot water as wax melts at 147 deg. Next honey will readily absorb water so keeping the inside of the extractor wet will desolve the honey.
what method being used should consider what type of bearings or pivots are used. a lot of the extractors come apart to make cleaning easier. and to allow for the re lubing of the bottom pivot.
For me small ones I just take it outside and hose it out the larger a 5 gal bucket under the spout and a 2nd one to splash the water inside from.
Honey Judge, Beekeeping Display Coordinator, Armstrong Fair and Rodeo.

Offline LazyBkpr

  • Gold Member
  • Posts: 6842
  • Thanked: 205 times
  • Gender: Male
  • www.outyard.net
    • The Outyard
  • Location: Richland Iowa
Re: cleaning extractors
« Reply #4 on: June 27, 2014, 10:08:32 am »
5 gal bucket under the spout, run cool water through a hose nozzle to rinse off most of it. This will usually also take most of the wax stuck in the honey. Sometimes I fill two or three 5 gal buckets, just empty outide as necessary..  Once I have most of it rinced and sprayed I will close the spout and add three inches or so of slightly warmer water, use a wet rag and scrub.  Open spout and drain with another spraying to rinse.   If there is wax smeared anywhere, I spray with COLD water and flake it off.  About an hour process to clean the extractor when extracting is finished.
Drinking RUM before noon makes you a PIRATE not an alcoholic!

*Sponsor*

Offline riverbee

  • Gold Member
  • ****
  • Posts: 8924
  • Thanked: 410 times
  • Gender: Female
  • ***Forum Sponsor***
  • Location: El Paso Twp, Wisconsin
Re: cleaning extractors
« Reply #5 on: June 27, 2014, 10:22:55 am »
mine comes apart.  i take it outside.  lemon ammonia mixed with a little water in a spray bottle. 5 gallon bucket of warm water. joy dish wash soap. hose. interior is sprayed with the ammonia, combined with the warm water, gets all the wax off pronto. wash it up. let it drain out. hit it with the hose, and rinse clean, wipe down, re lube.  same with the basket, although sometimes easier to wash up in large laundry tub.
i keep wild things in a box..........™
if you obey the rules, you miss all the fun.....katherine hepburn
Forum Sponsor

Offline brooksbeefarm

  • Gold Member
  • ****
  • Posts: 2566
  • Thanked: 89 times
  • Location: fair grove, mo.
Re: cleaning extractors
« Reply #6 on: June 27, 2014, 10:38:12 am »
Take outside and purt it on a plastic tarp, 5 gal. bucket of warm soap and water, take basket out and scrub the tub with a rag. Then hit all of  it with a power washer, let dry and reuse or store. Yes it's a pain in the Butt, but has to be done :sad:. Jack

Offline Edward

  • Senior Member
  • ***
  • Posts: 199
  • Gender: Male
  • Location: Bönan Sweden
Re: cleaning extractors
« Reply #7 on: June 29, 2014, 12:37:46 am »
Pour hot water in it so it covers the bottom put the lid on and let it stand over night.
The water will dissolve all the honey because the honey will dissolve in the humidity.
A high pressure hose is also an option.
Be Careful with detergents that could contaminate the next honey extraction.

mvh Edward  :P
"Well," said Pooh, "what I like best-" and then he had to stop and think. Because although Eating Honey was a very good thing to do, there was a moment just before you began to eat it which was better than when you were.

Offline ablanton

  • Regular Member
  • **
  • Posts: 95
  • Gender: Male
    • Blanton Apiaries
  • Location: Asheboro, NC
Re: cleaning extractors
« Reply #8 on: June 29, 2014, 10:05:57 pm »
Well, LazyBkpr's method looks almost identical to the way I've been doing it.  I must admit, though . . . Slowmodem's method looks pretty tempting!  :D
Andy

Offline apisbees

  • Global Moderator
  • Gold Member
  • *******
  • Posts: 3723
  • Thanked: 331 times
  • Gender: Male
  • Location: Vernon B.C.
Re: cleaning extractors
« Reply #9 on: June 30, 2014, 09:49:41 pm »
Also it doing maltible extractings have a precut plastic sheet to keep dust and bees out and cover till the next extraction at the end of the season and then wash it.
Honey Judge, Beekeeping Display Coordinator, Armstrong Fair and Rodeo.

Offline DonMcJr

  • Senior Member
  • ***
  • Posts: 204
  • Gender: Male
    • MichiganOutdoorsman
  • Location: SE Michigan
Re: cleaning extractors
« Reply #10 on: August 04, 2014, 08:02:34 pm »
I fill it with cold water and slowly crank a bit and drain. Repeat...and repeat til clean...

I NEVER use any chemicals...
President/Founder of Pine River Beekeeping Club  Goodells, MI in St. Clair County
Check out our Facebook Page >>> https://www.facebook.com/PineRiverBeekeepingClub?ref=hl

Offline Bamabww

  • Senior Member
  • ***
  • Posts: 343
  • Thanked: 4 times
  • Gender: Male
  • Location: Moulton, Alabama in the Fairfield community
Re: cleaning extractors
« Reply #11 on: August 04, 2014, 09:33:11 pm »
I have an easy and the lazy man's way to clean my extractor. I lay my 100' water hose out in the sun and fill it with water. A couple of hours later, carry my extractor outside, close the drain, and spray it down. Open the drain and keep spraying until it is clean. This way I can spray the frame holders and tank at the same time without any need to disassemble it, which is a PITA. I usually take a towel and wipe it dry. Been working for 4 years this way. I set it a 50 gallon heavy duty garbage bag and pull the bag up as far as it will go around the extractor, which is almost all the way to the top. Drop the cardboard box it came it back over it and store it my shed.
Wayne

Offline blueblood

  • Gold Member
  • ****
  • Posts: 1768
  • Thanked: 39 times
  • Gender: Male
    • https://www.facebook.com/scottshoneyandlipbalms
  • Location: Central Indiana, USA
Re: cleaning extractors
« Reply #12 on: August 05, 2014, 09:50:59 am »
I spray mine out with the hose, spray with 1/10 bleach spray, rinse, dry.

Offline Riverrat

  • Gold Member
  • ****
  • Posts: 2169
  • Thanked: 56 times
  • Location: oxford kansas
Re: cleaning extractors
« Reply #13 on: September 05, 2014, 11:21:44 am »
I let the bees clean it out, then wash with warm soapy water. When letting bees clean it out, make sure no hives are close to the extractor.
"no man ever stood so tall as one that  stoops to help a child"

Forum Supporter

Offline Perry

  • Global Moderator
  • Gold Member
  • *******
  • Posts: 7382
  • Thanked: 390 times
  • Gender: Male
    • Brandt's Bees
  • Location: Annapolis Valley, Nova Scotia
Re: cleaning extractors
« Reply #14 on: September 05, 2014, 05:39:16 pm »
Rinse out with cold water. Wash the inside with warm soapy water, flush and rinse, rinse, rinse. I would use a small pressure washer if I was able (and had one).
Hmmmm, sounds like a good Christmas present.  :)
"It is not the man who has too little, but the man who craves more, that is poor."      
Forum Supporter

Offline Papakeith

  • Senior Member
  • ***
  • Posts: 533
  • Thanked: 7 times
  • Gender: Male
    • Salisbury Farm Apiary
  • Location: RI
Re: cleaning extractors
« Reply #15 on: October 19, 2014, 08:19:08 am »
I just use water from a hose and my hand to wipe it down until I can't feel a film anymore.  Since the bees aren't interested in it I guess I got all of the honey out.
I'm starting to think that the bees are keeping me...